Toronto Rocket

Toronto Rocket
Toronto Rocket subway train at Rosedale Station
View along full length of train
In service 2011–present
Manufacturer Bombardier Transportation
Built at Thunder Bay, Ontario
Family name Movia
Replaced H4, H5, H6
Constructed 2008–present
Number under construction 80 six-car trains on order[1][2][3]
Formation 6-car set (Line 1), 4-car set (Line 4)
Fleet numbers 5381–6196[4]
Capacity 64–68 (seated/per car)
1458 (full train, crush load)[5]
Operator(s) Toronto Transit Commission
Depot(s) Wilson Subway Yard
Davisville Subway Yard
Line(s) served Yonge–University
Sheppard
Specifications
Car body construction Stainless steel[6]
Car length 23.190 m (76.08 ft)[4]
Height 3.137 m (10.29 ft)[4]
Doors 8 sets (4 sets per side) per car
Maximum speed 88 km/h (55 mph)[4] train max
75 km/h (47 mph) service revenue max
Weight 205,000 kg (202 long tons; 226 short tons) (per trainset); 34,167 kg (33.627 long tons; 37.663 short tons) per car[4]
Traction motors Bombardier MITRAC three phase AC
Power output 155 kW (207.858 hp) per motor
3,100 kW (4,157.168 hp) per 6-car train
Acceleration 0.90 m/s2 (3.0 ft/s2) (limited)
Deceleration 1.35 m/s2 (4.4 ft/s2) (service),
1.5 m/s2 (4.9 ft/s2) (emergency)
Auxiliaries 120/208 V AC battery auxiliary
Electric system(s) 600 V DC (third rail)
Current collection method Contact shoe
Braking system(s) Regenerative and pneumatic
Safety system(s) Emergency evacuation ramps at each end of trainset
Track gauge 4 ft 10 7⁄8 in (1,495 mm)

The Toronto Rocket (TR) is the fifth and latest series of rolling stock used in the Toronto subway system in Toronto, Ontario, Canada. Owned and operated by the Toronto Transit Commission (TTC), the trains were built by Bombardier Transportation in Thunder Bay, Ontario to replace the last remaining H-series trains as well as increase capacity for the Spadina subway extension to Vaughan. They operate in a six-car configuration on Line 1 Yonge–University and a four-car configuration on Line 4 Sheppard. The sets are stored and maintained at the Wilson and Davisville Yards.

The TR series is the newer of the two currently active series of rolling stock on the heavy-rail lines in the Toronto subway network, featuring a completely new design based on the Movia family of trains. They are notable as the first subway trains in North America equipped with full-open gangways, which allows passengers to see and walk through the entire length of the train. They are currently the only ones in Toronto compatible with the communications-based train control (CBTC) system, which will replace the current signaling system in several phases on Lines 1 and 4 between 2017 and 2019 (starting with the Line 1 extension to the Vaughan Metropolitan Centre, which opened on December 17, 2017) and also has the ability to operate with one staffer (a system that is currently in place on Lines 3 and 4) who plays the dual role of driving the train and opening/closing the doors.

The trains were designated under the production name as T35A08 before the name "Toronto Rocket" was chosen through a contest open to the public.[7][8] They are jointly funded by the City of Toronto (via Toronto Transportation Services), the Province of Ontario (via the Ministry of Transportation), and the Government of Canada (via Transport Canada).

History

The initial order was signed in 2006 for the delivery of 234 cars, making 39 six-car fixed trains, which allowed for the retirement of the H4 and H5 subway cars. Manufacturing of the TRs began in 2008. Delivery was expected to begin in late 2009, and they were scheduled to enter passenger service in early 2010. However, delivery was delayed by the bankruptcy of a key part manufacturer, Curtis Doors, which was to install door components for the TTC's TR subway trains.[4][9][10]

On May 6, 2010, the TTC voted to exercise a contract option with Bombardier for an additional 186 cars, making 31 six-car fixed train sets. This allowed for the retirement of the older H6 series trains, and to have enough TR trains to meet future ridership demands for the opening of the Spadina Subway extension to Vaughan Metropolitan Centre station (signed as "Vaughan" on the TR train's exterior destination signs for brevity), which was then scheduled for opening in mid-2015 (in time for the opening of that summer's Pan Am Games).[2][11] However, the opening of the extension was delayed until December 17, 2017.[12][13]

On October 1, 2010, the first train set (5391-5396) was delivered to Wilson Yard. It was unveiled to the public and media at Downsview station (later renamed Sheppard West) on October 14, 2010.[14]

Between October 2010 and July 2011, the TR trains underwent a series of testing and training runs on Line 1. The first TR trainset (5411-5416) entered passenger service on Line 1 on July 21, 2011. A further 10 train sets (60 cars) were authorized in March 2014 to bring the total to 80 six-car train sets and 480 cars.[3] In March 2015, the TTC reported that the T1 trains running on Line 4 would have to be replaced with TR trains before conversion of Line 1 to automatic train control (ATC) in 2020, and that TTC would report soon on the option of converting an existing six-car train to a four-car train to test One Person Train Operation (OPTO) (which was in place on the ICTS trains on Line 3 Scarborough since its inception).[15] They entered service on Line 4 on May 30, 2016 with two crew members, before switching over to OPTO on October 9, 2016.[16]

In the summer of 2016, some TR trains were used on Line 2 to address the shortage of T1s caused by faulty air-conditioning units after Toronto Mayor John Tory accepted a challenged posted on Twitter to ride a hot T1 on Line 2 during a hot day.[17]

Design

The TR series trains are similar to that of the T-series cars, also built by Bombardier in the same facility, but have several new features that make them more accessible and user-friendly for passengers. They include:

  • A four or six-car fixed configuration with full open interior gangways, departing from the married pair of previous models, allowing riders to move freely from one end to the other. This led to an increase in capacity by 10% on the lines in which they were used.
  • Double the number of accessible seats for passengers using mobility aids per car compared to the T-series, with automatic flip-up seats to accommodate devices such as walkers, wheelchairs, bicycles and strollers. These are marked with exterior blue lights on each car adjacent to the doorway nearest to the accessible seating area. As with all TTC vehicles, these designated priority seats are covered in blue velour; general seating is covered in red velour.
  • A new colour scheme consisting of white cream walls, stainless steel doorways, and grey floors with red, high-visibility floor markings and red-painted stanchions to assist visually impaired passengers. Antimicrobial properties are present on these and on various other surfaces.
  • Enhanced passenger information systems in all cars, consisting of digital orange LED signs that indicate the name of the next stop and if the station is an interchange or terminal station, visual arrows and, as of 2015, audible messages (which is based on direction of train movement) that indicate which side doors will open on at the next stop, and electronic LED route maps that indicate which stations have been served and which stations are next to follow (interchange stations are lit in yellow dots). The TR trains are equipped with a warning message when the doors are closing alongside the three-tone chime "Please stand clear of the doors". Video screens are also present, displaying safety messages, TTC-related advertising and the name of the next station at the bottom.
  • Improved safety systems for use in the event of an emergency, such as two-way passenger assistance intercoms for passengers to communicate with the train crew and built-in evacuation ramps located at the ends of the train to allow for faster and easier evacuation. Each car also has four ceiling-mounted CCTV cameras for passenger safety and security. Footage is recorded and can be reviewed in the event of an incident.
  • Full-width operator cabs located at the ends of the train for the enhanced safety and security of operating personnel. They are equipped with doorways to allow operators to access the cab unit directly from the subway platform and prevent exposure to the public while performing operating duties. The railfan window (which allows passengers to see from the front or rear of the train), present on older series trains in the emergency doorway, is replaced with a one-way mirror in the cab access door from the interior, though it is still possible to see through the window. The cab also has a slanted end design for better aerodynamics with bright orange digital LED exterior destination and three-digit run number signs in place of the rollsigns used on previous models.

Retrofits

In February 2013, the TTC began a trial phase with the installation of exterior door chimes (above each set of doorways) on the TR trains. Set 5461-5466 was the first to be retrofitted, followed by set 5851-5856 in May 2014.

Additional yellow plastic straps (placed underneath the HVAC units) along with audible door opening side announcements (based on direction of train travel), which is played after the "Arriving at" station announcement (except for terminal stations) to better assist visually impaired passengers have been installed in all TR trains as of January 2016. Meanwhile, it was reported that all TR trains were scheduled to be retrofitted with external speakers, together with exterior side destination signs that audibly announce the route and destination of the train along with the door chimes, by (approximately) the end of 2016. However, as of October 2017, not all TR trains have yet been upgraded with these features.[6][18][19][20][21]

Criticism

Tendering process

During the tendering process, Siemens Canada (see Siemens Modular Metro) was seen a possible competitor to the Bombardier bid.[22][23] Councillors Karen Stintz (who later also served as TTC chair), Denzil Minnan-Wong, and Rob Ford (who became mayor in late 2010 but died in March 2016) were opposed to sole-sourcing the contract to Bombardier. They alleged that many sole-source advocates had union ties and were thus not interested in getting the best financial deal available to the city.[24]

Mobility issues

TTC riders holding on to an overhead AC unit for stability.

In late September 2011, it was reported that some passengers with mobility devices were experiencing difficulties while entering and/or exiting the then-new TR trains. TTC officials noted that this could either be because the train was sitting too high in relation to the level of the platform or be the result of the train's door threshold, which is not parallel with the platform and/or the number of passengers riding on the train. They were actively looking for ways to solve the problem.[25]

To increase mobility, the train does not have centre poles, leaving standing riders with fewer places to hold. There are swinging handles hanging from a lateral pole along the length of each car near the ceiling, except near car ends, where an overhead ventilation unit is located.[26]

"Teething issues"

In March 2012, TTC officials admitted that the door threshold incidents were the result of "teething issues". Another issue that was acknowledged involves a short delay in opening of the doors when the train pulls into a station. On the older train models, the door release interlock could be triggered just before or immediately after the vehicle came to a complete stop. The TR trains must come to a complete stop with confirmation from the onboard computer before the door interlock can be released and the guard can open the doors. This causes a one- or two-second delay from the time the train appears stopped and the time the doors open.[27]

In December 2012, the TTC announced that it had demanded high-level meeting with Bombardier regarding ongoing performance problems related to "teething issues" with the doors. TTC officials admitted at the time that the new TR trains cannot move until all doors are fully closed (as with the older trains) and if the doors fail to close thrice consecutively fully, the TR train would require a system reboot, meaning that the train would have to be pulled out of service until it was resolved. This has led to several delays on Line 1.[28]

Increased brightness

The TR trains feature a significantly brighter interior than previous models, which some passengers find distracting.[29][30]

See also

References

  1. ↑ "TTC Service Summary - March 29,2015 to May 9, 2015" (PDF). Toronto Transit Commission. March 6, 2015. Retrieved 2015-03-22.
  2. 1 2 "TTC approves 186 more subway cars". TBNewsWatch.com. 2010-05-06. Retrieved 2012-12-05.
  3. 1 2 "Procurement Authorization Amendment to Purchase 10 Additional Toronto Rocket Train Sets - Purchase Order No. C31PD05761" (PDF). Toronto Transit Commission. 2015-03-26. Retrieved 2015-03-22.
  4. 1 2 3 4 5 6 "New Subway Train - The Toronto Rocket". Toronto Transit Commission. May 2011. Retrieved 2012-12-05.
  5. ↑ "Technical data - Metro Subway Train "Toronto Rocket" – Toronto, Canada". Bombardier Transportation. Retrieved 2016-09-04.
  6. 1 2 "Toronto Rocket Subway Train - Toronto, Canada (Project Overview)". Bombardier Transportation. Retrieved 2012-12-05.
  7. ↑ Bow, James (2012-04-21). "The Toronto Rocket Cars (T35A08)". Transit Toronto. Retrieved 2012-12-05.
  8. ↑ ""Toronto Rocket" A Train with a new Name". Marketwired. 2006-10-13. Retrieved 2012-12-05.
  9. ↑ Alcoba, Natalie (2010-01-14). "New TTC trains delayed after door company goes belly up". National Post. Retrieved 2010-01-15.
  10. ↑ Bow, James (2009-09-22). "TTC Looking For New Subway Cars in October". Transit Toronto. Retrieved 2012-12-05.
  11. ↑ "Procurement Authorization Amendment - option to purchase 31 additional new subway train sets (for H6 subway car replacement and TYSSE)" (PDF). Toronto Transit Commission. 2010-05-06. Retrieved 2012-12-05.
  12. ↑ "Toronto-York Spadina Subway Extension – Schedule and Budget Change" (PDF). Toronto Transit Commission. 2015-03-26. Retrieved 2015-03-23.
  13. ↑ Westoll, Nick (September 5, 2017). "Toronto-York Spadina Subway Extension scheduled to open in mid-December". Global News. Retrieved September 6, 2017.
  14. ↑ "TTC unveils new subway cars". CP24. 2010-10-14. Retrieved 2012-12-05. [ TTC unveils new subway cars] CP24, published on October 14, 2010
  15. ↑ "Procurement Authorization - Procurement Authorization Change Directive to the Toronto Rocket (TR) Supplier for the Design Provisions for Train Door Monitoring (TDM) System" (PDF). Toronto Transit Commission. 2015-03-26. Retrieved 2015-03-22.
  16. ↑ http://www.cbc.ca/news/canada/toronto/sheppard-subway-line-gets-new-toronto-rocket-trains-1.3607811
  17. ↑ "Feeling the heat, passengers? TTC working to fix its 'hot car' problem on Line 2". CBC News.
  18. ↑ TTC set to fix most annoying feature of Rocket trains | BlogTO. blogto.com. Retrieved on 2015-01-13.
  19. ↑ "Toronto Rocket: Overview and Key Features". Toronto Transit Commission. 2008. Retrieved 2012-12-05.
  20. ↑ TTC tweaks its new Rocket trains
  21. ↑ Oakland, Ross (2012-04-20). "New TTC train, the Rocket, takes away some of the 'fun factor'". Toronto Star. Toronto. Retrieved 2012-12-05.
  22. ↑ "TTC approves Bombardier deal". CBC News. 2006-08-31. Retrieved 2012-12-05.
  23. ↑ Kalinowski, Tess (2009-04-18). "A streetcar now for city of tomorrow". Toronto Star. Retrieved 2012-12-05.
  24. ↑ "Made in Canada Matters! - Why the City of Toronto Should Purchase 'Made In Canada' Products" (PDF). Toronto & York Region Labour Council. 2006-10-03. Retrieved 2012-12-05.
  25. ↑ Kalinowski, Tess (2011-09-25). "Wheelchair users can't always roll onto the Rocket". Toronto Star. Retrieved 2012-12-05.
  26. ↑ Matt Gurney: Fixing the doors on new TTC's subway cars an opportunity to change other things as well. National Post. Retrieved on 2013-07-26.
  27. ↑ Kalinowski, Tess (2012-03-30). "TTC working out bugs on new subway trains". Toronto Star. Retrieved 2012-12-05.
  28. ↑ Grewal, San (2012-12-04). "Toronto's new Rocket subway trains malfunctioning". Toronto Star. Retrieved 2012-12-05.
  29. ↑ TTC launches brighter, more open subway cars | Toronto Star. Thestar.com (2010-10-15). Retrieved on 2013-07-26.
  30. ↑ What should the TTC do to improve its Rocket trains?. Blogto.com (2012-12-05). Retrieved on 2013-07-26.

Media related to Toronto Rocket at Wikimedia Commons

  • "New Subway Train - The Toronto Rocket". Toronto Transit Commission. May 2011. Retrieved 2012-12-05.
  • "New TTC Subway Cars". UrbanToronto. 2006-01-29. Retrieved 2012-12-05.
This article is issued from Wikipedia. The text is licensed under Creative Commons - Attribution - Sharealike. Additional terms may apply for the media files.