Convair 880

Convair 880
A Delta Air Lines 880 in flight shortly after delivery: Delta had the second-largest fleet, behind TWA.
Role	Narrow-body jet airliner
National origin	United States
Manufacturer	Convair
First flight	January 27, 1959
Introduction	May 1960 with Delta Air Lines
Status	Retired
Primary users	Trans World Airlines Delta Air Lines Japan Airlines Swissair
Produced	1959-1962
Number built	65
Variants	Convair 990 Coronado

The Convair 880 is an American narrow-body jet airliner produced by the Convair division of General Dynamics. It was designed to compete with the Boeing 707 and Douglas DC-8 by being smaller and faster, a niche that failed to create demand. When it was first introduced, some aviation circles claimed that at 615 mph (990 km/h), it was the fastest jet transport in the world.^[1] Only 65 Convair 880s were produced over the lifetime of the production run from 1959 to 1962, and General Dynamics eventually withdrew from the airliner market after considering the 880 project a failure. The Convair 990 was a stretched and faster variant of the 880.

Design and development

Convair began development of a medium-range commercial jet in April 1956, to compete with announced products from Boeing and Douglas. Initially the design was called the Skylark, but the name was later changed to the Golden Arrow, then Convair 600 and then finally the 880, both numbers referring to its top speed of 600 mph (970 km/h) or 880 ft/s (268 m/s). It was powered by General Electric CJ-805-3 turbojets, a civilian version of the J79 which powered the Lockheed F-104 Starfighter, McDonnell Douglas F-4 Phantom,^[2] and Convair B-58 Hustler.

The first example of the initial production version, the Model 22, made its maiden flight on January 27, 1959.^[3] No prototype was built. After production started, the Federal Aviation Administration mandated additional instrumentation, which Convair added by placing a "raceway" hump on the top of the fuselage, rather than ripping apart the interiors over the wing area. The final assembly of the 880 and 990 took place at the Convair facilities in San Diego, California.^[4]

The airliner never became widely used and the production line shut down after only three years. The 880's five-abreast seating made it unattractive to airlines, while Boeing was able to out-compete it with the Boeing 720, which could be sold at a significantly lower cost, as it was a minimal modification of the existing 707. In addition, the General Electric engines had a higher specific fuel consumption than the Boeing's Pratt & Whitney JT3Cs.

General Dynamics lost around $185 million over the lifetime of the project, although some sources estimate much higher losses. The aircraft were involved in 17 accidents and five hijackings.

A modified version of the basic 880 was the "-M" version which incorporated four leading-edge slats per wing, Krueger leading-edge flaps between the fuselage and inboard engines, power-boosted rudder, added engine thrust, increased fuel capacity, stronger landing gear, greater adjustment to seating pitch, and a simpler overhead compartment arrangement.^[5]

A more major modification to the 880 became the Convair 990, produced in parallel with the 880-M between 1961 and 1963. Swissair named theirs Coronado, after an island off the San Diego coast and where the first 990 landed.^[6]

Operational history

Trans World Airlines was the major operator of the Convair 880. One of their aircraft departs from Chicago O'Hare on a scheduled service in April 1971.

The design entered service with Delta Air Lines in May 1960, slightly modified as the 880-22m, having newer version 805-3B engines. The 880s were flown by Cathay Pacific, Delta, Japan, Northeast, Swissair, TWA, and VIASA.

As they left commercial service, many 880s were bought by American Jet Industries for various uses. One example was converted to freighter use in 1974, and flew until 1982 with various companies. Another was used to train FAA flight examiners until it was destroyed by a minor explosion in the cargo hold in 1995. Most of the remaining examples were scrapped by 2000.

Delta Air Lines operated 17 Convair 880s between early 1960 and early 1974.

The United States Navy acquired one 880-M in 1980, modifying it as an in-flight tanker. It had been purchased new from Convair by the FAA, and used for 18 years.^[7] Unofficially designated UC-880, it was assigned to the Naval Air Test Center at NAS Patuxent River, Maryland, and employed in Tomahawk Cruise Missile testing and aircraft refueling procedures.^[8] The sole UC-880 was damaged in a cargo hold explosive decompression test at NAS Patuxent River, Maryland, in 1995.^[9] The aircraft managed to remain theoretically controllable via backup systems unique to the 880 and 990.^[10]

Operators

One of the first 880s, in the factory gold, white, and black scheme

The Convair UC-880 aircraft refuels an F-14D Tomcat.

The flight deck of a new Convair 880

A UC-880 assigned to Naval Air Test Center, Patuxent River, employed in Tomahawk cruise missile testing and refueling aircraft procedures

Accidents and incidents

• On May 23, 1960, Delta Air Lines Flight 1903, a CV-880-22-1 (N8804E), crashed on takeoff at Atlanta Municipal Airport (now Atlanta Hartsfield-Jackson International Airport), resulting in the loss of all four crew members. This flight was to be a training sortie for two Delta captains who were being type-rated on the 880. At rotation, the aircraft pitched nose up, rolled left, and then back more steeply to the right, at which time it struck the ground, broke apart, and was consumed by a fire.^[11]
• On August 26, 1966, a Japan Air Lines CV-880-22M-3 (JA8030) crashed on takeoff from Haneda Airport during a training flight, killing all five crew members. When the nose lifted up, the aircraft yawed to the left, for reasons unknown. The number one engine struck the runway and the aircraft left the runway and the nose went back down. All four engines separated, as well as the nose and left main gear, and the aircraft caught fire. The aircraft was leased from Japan Domestic Airlines.^[12]
• On November 5, 1967, Cathay Pacific Flight 033, a CV-880-22M-3 (VR-HFX) overran the runway on takeoff from Kai Tak Airport following a loss of control after the right nosewheel blew, killing one of 127 on board.^[13]
• On November 20, 1967, TWA Flight 128 crashed on approach to Cincinnati/Northern Kentucky International Airport. Seventy people were killed and 12 survived.^[14]
• On June 24, 1969, Japan Air Lines Flight 90, a CV-880-22M-3 (JA8028, Kikyo), crashed on takeoff from Grant County Airport, killing three of the five crew members. The flight was to simulate a takeoff with one engine out. Power was reduced to the number four engine during takeoff, but the aircraft continued to yaw to the right until the number four engine struck the runway. The aircraft slid off the runway and caught fire.^[15]
• On June 15, 1972, a bomb exploded on board Cathay Pacific Flight 700Z over Pleiku, South Vietnam, killing all 81 passengers and crew on board.^[16]
• On December 20, 1972, North Central Airlines Flight 575, a McDonnell Douglas DC-9-31, collided during its takeoff roll with Delta Air Lines Flight 954, a Convair 880 (N8807E), as the Convair 880 taxied across the runway at O'Hare International Airport in Chicago, Illinois. Only two people on the Convair 880 were injured, but 10 people died and 15 were injured on board the DC-9.^[17]
• On August 20, 1977, a Monarch Aviation CV-880-22-2 (N8817E) struck trees and crashed shortly after takeoff from Juan Santamaria International Airport due to overloading, killing the three crew.^[18]
• On November 3, 1980, a Latin Carga CV-880-22-2 (YV-145C) crashed on takeoff from Simon Bolivar International Airport during a crew training flight, killing the four crew.^[19]
• On May 11, 1983, a Groth Air CV-880-22-2 (N880SR) burned out at Juarez International Airport.^[20]
• In October 1986, an FAA CV-880-22M-3 (N5863) was destroyed in a test with anti-misting kerosene fuel additive at Mojave, California.^[21]

Surviving aircraft

Elvis' Convair 880, named Lisa Marie after his daughter

Convair 880 in private ownership in South Africa

The cockpit instrument panel of the USN UC-880

• 1 – Cockpit on display at the Delta Flight Museum in Atlanta, Georgia^[22]
• 3 – Forward fuselage in storage at the Aviation Hall of Fame and Museum of New Jersey in Teterboro, New Jersey^[23][24], Was placed on loan by James Douglas Scroggins III of Scroggins Aviation of Las Vegas, Nevada ^[25]",
• 23 – Forward fuselage in storage with Scroggins Aviation in Mojave, California: This airframe was cut up for scrap in April 2007, with the forward fuselage being saved for use in a museum.^[26] In August 2018, the Tillamook Air Museum announced that it was bringing ship 23 to their Museum in Tillamook, Oregon, where it would be the only Convair 880 on display anywhere on the west coast. The cockpit was placed on loan by James Douglas Scroggins III of Scroggins Aviation in Las Vegas, Nevada ^[27][28]
• 35 – In storage with Scroggins Aviation in Mojave, California, with it's headquarters in Las Vegas, Nevada ^[29], James Douglas Scroggins III of Scroggins Aviation saved the last passenger Convair 880 jetliner in the world,^[30][31]
• 38 Lisa Marie – On display at Graceland in Memphis, Tennessee:^[32][33] This airframe was used by Elvis Presley and is named after his daughter. It is the only properly preserved airframe. It was formerly in commercial service with Delta.^[34] In January 2015, it was put up for sale and eventually bought back by Elvis Presley Enterprises. The aircraft is part of the Presley Museum collection.^[35]
• 58 – Converted into lodge in East London, South Africa:^[36] This airframe was converted into a business jet in the 1970s (registration N88CH). It was purchased by the Ciskei government in 1987 intended for use by president Lennox Sebe, but remained at Bhisho Airport for several years due to a lack of funds to make it airworthy. In 1992, it was bought by Billy Nel (now Eastern Cape Provincial Finance MEC), who had it transported to his private residence north of East London, South Africa. The 1970s, VIP interior with couches, beds and a bar remain intact and it is used for private functions. One of the engines was donated to the Stutterheim Engine Museum.^{[9][37][38][39]}

Specifications (880 Model 22 and 22-M)

Data from Jane's All The World's Aircraft 1965-66 ^[40]

General characteristics

• Crew: 3
• Capacity: 110 passengers
• Payload: 24,000 lb (10,900 kg)
• Length: 129 ft 4 in (39.42 m)
• Wingspan: 120 ft 0 in (36.58 m)
• Height: 36 ft 3¾ in (11.07 m)
• Wing area: 2,000 sq ft (185.8 m²)
• Aspect ratio: 7.2
• Empty weight: 94,000 lb (42,730 kg)
• Max. takeoff weight: 193,000 lb (203,400 lb [880-M]) (87,730 kg)
• Powerplant: 4 × General Electric CJ-805-3B turbojet, 11,650 lbf (51.95 kN) each

Performance

• Cruise speed: 610 mph^[41] (max. mach: .89 [approx. 615 MPH]) (535 knots, 990 km/h) (max cruise at 22,500 ft (6,860 m)
• Stall speed: 111 mph (97 knots, 179 km/h)
• Range: 3,385 mi (3,750 880-M) (2,943 nmi, 4,430 km)
• Service ceiling: 41,000 ft (12,500 m) (max cruise altitude)

See also

Related development

• Convair 990 Coronado

Aircraft of comparable role, configuration and era

• Boeing 720

Related lists

• List of jet airliners

References

External links

Wikimedia Commons has media related to Convair 880.

• Aerofiles — Data and photos of Convair aircraft
• Goleta Air and Space Museum — Information and pictures of various Convair 880s.
• ConvairJet.com — An organization focused on preserving several Convair 880s.
• Aviation-Safety.net — Convair 880 Accident Database.
• Aviation History Online — Convair CV880
• YouTube video of a Delta Airlines Convair 880