Air Transat Flight 236

Air Transat Flight 236
The Airbus A330-243 involved in the accident.
Accident
Date August 24, 2001 (2001-08-24)
Summary Fuel exhaustion caused by fuel leak due to improper maintenance and pilot error
Site Lajes Air Force Base,
Terceira Island, Azores, Portugal
Aircraft
Aircraft type Airbus A330-243
Operator Air Transat
Registration C-GITS
Flight origin Toronto Pearson Int'l Airport
Toronto, Ontario, Canada
Destination Portela Airport
Lisbon, Portugal
Passengers 293
Crew 13
Injuries 18 (16 minor; 2 serious)
Survivors 306 (all)

Air Transat Flight 236 was a transatlantic flight bound for Lisbon, Portugal, from Toronto, Canada, that lost all engine power while flying over the Atlantic Ocean on August 24, 2001. The Airbus A330 ran out of fuel due to a fuel leak caused by improper maintenance. Captain Robert Piché, 48, an experienced glider pilot, and First Officer Dirk de Jager, 28, flew the plane to a successful emergency landing in the Azores, saving all 306 people (293 passengers and 13 crew) on board.[1] Most of the passengers on the flight were Canadians visiting Europe and Portuguese expatriates returning to visit family in Portugal.

Accident

Flight TS 236 took off from Toronto at 00:52 (UTC) on Friday, August 24, 2001 (local time: 8:52 pm (ET) on Thursday, August 23), bound for Lisbon, Portugal. There were 293 passengers and thirteen crew members on board. The aircraft was an Airbus A330-243 registered as C-GITS[2] that first flew on March 17, 1999,[3] configured with 362 seats and placed in service by Air Transat on April 28, 1999.[3] It was powered by two Rolls Royce Trent 772B-60 engines capable of delivering 71,100 lbf (316 kN) thrust each. Leaving the gate in Toronto, the aircraft had 46.9 tonnes of fuel on board, 4.5 tonnes more than required by regulations.[4][Note 1]

Unknown to the pilots, at 04:38, fuel began to leak from the right engine.[4](p23) At 05:03 UTC, more than 4 hours into the flight, the pilots noticed low oil temperature and high oil pressure on engine #2.[4](pp7,23) Although these readings were an indirect result of the fuel leak, there was no obvious reason for the pilots to consider that as the cause. Consequently, Captain Robert Piché, who had 16,800 hours of flight experience,[4](p12) and First Officer Dirk DeJager, who had 4,800 flight hours,[4](p12) suspected they were false warnings and shared that opinion with their maintenance control centre, who advised them to monitor the situation.[4](p56)

At 05:36 UTC, the pilots received a warning of fuel imbalance. They followed a standard procedure to remedy the imbalance by transferring fuel from the left wing tank to the right wing tank. Unknown to the pilots, the aircraft had developed a fuel leak in a line to the #2 (right) engine. The transferred fuel was lost through that leak. The fractured fuel line, which was leaking at about one gallon per second, caused a higher than normal fuel flow through the fuel-oil heat exchanger (FOHE), which in turn led to a drop in oil temperature and a rise in oil pressure for the #2 engine.[5]

Azores
Toronto
Lisbon
Locations in the North Atlantic related to Flight 236

At 05:45 UTC, the pilots decided to divert to Lajes Air Base in the Azores. They declared a fuel emergency with Santa Maria Oceanic air traffic control three minutes later.

At 06:13 UTC, while still 150 nautical miles (280 km) from Lajes and at 39,000 feet (12,000 m), engine #2 flamed out due to fuel starvation.[6] Captain Piché then initiated a descent to 33,000 feet (10,000 m), which was the proper single-engine altitude for the weight of the plane at that time. Ten minutes later, the crew sent a Mayday to Santa Maria Oceanic air traffic control.

Three minutes later, at 06:26 UTC and approximately 65 nautical miles (120 km; 75 mi) from Lajes Air Base, engine #1 also flamed out requiring the plane to glide the remaining distance.[4](p8) Without engine power, the plane lost its primary source of electrical power. The emergency ram air turbine deployed automatically to provide essential power for critical sensors and instruments to fly the aircraft. However, the aircraft lost its main hydraulic power, which operates the flaps, alternate brakes, and spoilers. The slats would still be powered, however, when the flaps #1 position was selected.

Military air traffic controllers guided the aircraft to the airport with their radar system. The descent rate of the plane was about 2,000 feet (600 metres) per minute. They calculated they had about 15 to 20 minutes left before they would be forced to ditch in the ocean. The air base was sighted a few minutes later. Captain Piché had to execute one 360 degree turn, and then a series of "S" turns, to dissipate excess altitude.

At 06:45 UTC, the plane touched down hard, approximately 1,030 feet (310 m) past the threshold of Runway 33, at a speed of approximately 200 knots (370 km/h), bounced once and then touched down again, approximately 2,800 feet (850 m) from the threshold. Maximum emergency braking was applied and retained, and the plane came to a stop 7,600 feet (2,300 m) from the threshold of the 10,000-foot (3,000 m) runway. Since the anti-skid and brake modulation systems were inoperative, the eight main wheels locked up; the tires abraded and fully deflated within 450 feet (140 m).[4](p11) Fourteen passengers and two crew members suffered minor injuries, while two passengers suffered serious injuries during the evacuation of the aircraft. The plane suffered structural damage to the main landing gear and the lower fuselage.

Investigation

The Portuguese Aviation Accidents Prevention and Investigation Department (GPIAA) investigated the accident along with Canadian and French authorities.[7]

The investigation revealed that the cause of the accident was a fuel leak in the #2 engine, caused by an incorrect part installed in the hydraulics system by Air Transat maintenance staff as part of routine maintenance.[7] The engine had been replaced with a spare engine, lent by Rolls-Royce, from an older model which did not include a hydraulic pump. Despite the lead mechanic's concerns, Air Transat authorized the use of a part from a similar engine, an adaptation that did not maintain adequate clearance between the hydraulic lines and the fuel line. This lack of clearance, on the order of millimetres from the intended part,[7] allowed chafing between the lines to rupture the fuel line, causing the leak. Air Transat accepted responsibility for the accident and was fined 250,000 Canadian dollars by the Canadian government, which as of 2009 was the largest fine in Canadian history.[7]

Pilot error was also listed as one of the lead causes of the accident (for failing to identify the fuel leak). Nevertheless, the pilots returned to a heroes' welcome from the Canadian press as a result of their successful unpowered landing. In 2002, Captain Piché was awarded the Superior Airmanship Award by the Air Line Pilots' Association.[8]

Aftermath

The accident led to the French Directorate General for Civil Aviation (DGAC) and Federal Aviation Administration (FAA) issuing an Airworthiness Directive (AD),[9] requiring all operators of Airbus models A318, A319, A320 and A321 narrow body aircraft to revise the flight manual, stressing that crews should check that any fuel imbalance is not caused by a fuel leak before opening the cross-feed valve. The AD required all airlines operating these Airbus models to make revisions to the Flight Manual before any further flights were allowed. The FAA gave a 15-day grace period before enforcing the AD. Airbus also modified its computer systems; the on-board computer now checks all fuel levels against the flight plan. It now gives a clear warning if fuel is being expended beyond the specified fuel consumption rate of the engines. Rolls-Royce also issued a bulletin advising of the incompatibility of the relevant engine parts.

The aircraft was repaired and returned to service with Air Transat in December 2001, with the nickname "Azores glider". It was still in service with the airline as of July 2018.[3]

Dr. Margaret McKinnon, a postdoctoral psychology student at Baycrest Health Sciences in Toronto at the time, was a passenger on her honeymoon on Flight 236. She and colleagues recruited fifteen other passengers in a study of posttraumatic stress disorder (PTSD), published in August 2014 in the academic journal Clinical Psychological Science, which compared details recalled by passengers suffering from PTSD with those recalled by passengers without PTSD and with a control group.[10][11]

  • The events of Flight 236 were featured in "Flying on Empty", a Season 1 (2003) episode of the Canadian TV series Mayday[12] (called Air Emergency and Air Disasters in the U.S. and Air Crash Investigation in the UK and elsewhere around the world). The flight was also included in a Mayday Season 6 (2007) Science of Disaster special titled "Who's Flying the Plane?"[13]
  • MSNBC produced a report on the incident with the title "On a Wing and a Prayer", which first aired in the U.S. on August 7, 2005.[14]
  • The story of Robert Piché is depicted in the 2010 French Canadian biographical drama film Piché: The Landing of a Man (Piché: Entre ciel et terre, FR) culminating with the events on Flight 236.[15] Captain Piché is portrayed by both Genie Award-winning actor Michel Côté and his son Maxime LeFlaguais.

See also

Notes

  1. ↑ TSC236 was planned to depart CYYZ at 00:10 UTC1, with 47.9 metric tons of fuel, which included a 5.5 tons over and above the fuel required by regulations for the planned flight; the actual take-off time was at 00:52 with a reported 46.9 tons of fuel on board.[4]

References

  1. ↑ Crossette, Barbara (September 10, 2001). "Jet Pilot Who Saved 304 Finds Heroism Tainted". The New York Times. Retrieved August 21, 2007.
  2. ↑ "Canadian Civil Aircraft Register (C-GITS)". Transport Canada.
  3. 1 2 3 "Airbus A330 – MSN 271 – C-GITS: General information & flightlog". airfleets.net. Retrieved June 16, 2018.
  4. 1 2 3 4 5 6 7 8 9 "Accident Investigation Final Report – All Engines-out Landing Due to Fuel Exhaustion – Air Transat Airbus A330-243 marks C-GITS, Lajes, Azores, Portugal, 24 August 2001" (PDF). Portuguese Aviation Accidents Prevention and Investigation Department. Retrieved December 26, 2016.
  5. ↑ "Air Transat Flight 236: The Azores Glider" (PDF). Retrieved July 27, 2010.
  6. ↑ https://www.fss.aero/accident-reports/dvdfiles/PT/2001-08-24-PT.pdf
  7. 1 2 3 4 Mayday – S01E03 – Flying On Empty Air Transat flight 236 on YouTube
  8. ↑ "Robert Piché Given Award". Aero News Network. Aero News Network. 26 August 2002. Retrieved December 26, 2016.
  9. ↑ Airbus Model A318-100, A319-100, A320- 200, A321-100
  10. ↑ "PTSD clues gleaned from passengers on terrifying flight". CBC.ca. August 14, 2014.
  11. ↑ McKinnon, Margaret C.; Palombo, Daniela J.; Nazarov, Anthony; Kumar, Namita; Khuu, Wayne; Levine, Brian (July 1, 2015). "Threat of Death and Autobiographical Memory – A Study of Passengers From Flight AT236". Clinical Psychological Science. SAGE Publications. 3 (4): 487–502. doi:10.1177/2167702614542280. ISSN 2167-7026. PMC 4495962.
  12. ↑ "Flying on Empty". Mayday. Season 1. Episode 6. 2003. Discovery Channel Canada / National Geographic Channel.
  13. ↑ "Who's Flying the Plane?". Mayday. Season 6. Episode 3. 2007. Discovery Channel Canada / National Geographic Channel.
  14. ↑ "On a Wing and a Prayer (download)". MSNBC Reports. Retrieved March 26, 2018.
  15. ↑ "Entre ciel et terre review (in French)". cinoche.com. Archived from the original on July 22, 2010. Retrieved July 1, 2010.

Coordinates: 42°43′59″N 23°04′59″W / 42.733°N 23.083°W / 42.733; -23.083

This article is issued from Wikipedia. The text is licensed under Creative Commons - Attribution - Sharealike. Additional terms may apply for the media files.